Boeing 747SP

From Wikipedia, the free encyclopedia

Boeing 747SP
Boeing 747SP of launch customer Pan Am
Role Wide-body jet airliner
National origin United States
Manufacturer Boeing Airplane Company
First flight July 4, 1975
Introduction 1976 with Pan Am
Status In limited service
Primary users Pan Am (historical)
United Airlines (historical)
South African Airways (historical)
Iran Air (historical)
Produced 1976–1982, 1987–1989
Number built 45[1]
Developed from Boeing 747-100
Variants SOFIA

The Boeing 747SP (for Special Performance) is a shortened version of the Boeing 747 wide-body airliner, designed for a longer range. It is the highest flying subsonic passenger airliner, with a service ceiling of 45,100 feet (13,700 meters). Boeing needed a smaller aircraft to compete with the McDonnell Douglas DC-10 and Lockheed L-1011 TriStar tri-jet wide-bodies, introduced in 1971/1972. Pan Am requested a 747-100 derivative to fly between New York and the Middle East, a request also shared by Iran Air, and the first order came from Pan Am in 1973.

The variant first flew on July 4, 1975, was approved by the Federal Aviation Administration on February 4, 1976, and entered service that year with Pan Am.

The SP is 184 feet 9 inches (56.31 m) in length, 47 feet (14 m) shorter than the original 747 variants. Its main deck doors are reduced to four on each side to suit its lower capacity. The vertical and horizontal tailplanes are larger and its wing flaps have been simplified. With a 700,000-pound (320 t; 320,000 kg) maximum take-off weight, it can fly 276 passengers in three classes over 5,830 nautical miles [nmi] (10,800 km; 6,710 mi). One 747SP was modified into the Stratospheric Observatory for Infrared Astronomy (SOFIA). The last example was delivered in 1987; some were converted to transports of heads of state. Sales did not meet the expected 200 units, and only 45 aircraft were ultimately produced.[2]

Development[edit]

Iran Air 747SP from above, 47 ft (14 m) shorter than the 747, with four exit doors per side

The idea for the 747SP came from a request by Pan Am for a 747 variant capable of carrying a full payload non-stop on its longest route between New York and Tehran.[3] Joined with Pan Am's request was Iran Air; their joint interest was for a high-capacity airliner capable of covering Pan Am's New York–Middle Eastern routes and Iran Air's planned New York-Tehran route[4] (New York to Tehran was the longest non-stop commercial flight in the world for a short time). The aircraft was launched with Pan Am's first order in 1973, and the first example was delivered in 1976.[5][6][7]

A shorter derivative of the 747-100, the SP was developed to target two market requirements.[5] The first was a need to compete with the DC-10 and L-1011 while maintaining commonality with the 747,[5] which in its standard form was too large for many routes. Until the arrival of the 767, Boeing lacked a mid-sized wide-body to compete in this segment. The second market requirement was an aircraft suitable for the ultra-long-range routes emerging in the mid-1970s following the joint request. These routes needed not only longer range but also higher cruising speeds. Boeing could not afford to develop an all-new design, instead opting to shorten the 747 and optimize it for speed and range, at the expense of capacity.[8]

The last 747SP, built in 1987 for Abu Dhabi Amiri Flight

Originally designated 747SB for "short body", it was later nicknamed "Sutter's balloon" by employees after 747 chief engineer Joe Sutter.[9] Boeing later changed the production designation to 747SP for "special performance", reflecting the aircraft's greater range and higher cruising speed.[10] Production of the 747SP ran from 1976 to 1983. However, a VIP order[5] for the Abu Dhabi Amiri Flight led Boeing to produce one last SP in 1987. Pan Am was the launch customer for the 747SP, taking the first delivery, Clipper Freedom, on March 5, 1976.[10]

The 747SP was the longest-range airliner available until the 747-400 entered service in 1989. Despite its technical achievements, the SP never sold as well as Boeing hoped.[5] Increased fuel prices in the mid-1970s to early 1980s, the SP's heavy wings, high cost,[5] and reduced capacity, and the increased ranges of forthcoming airliners[5] were some of the many factors that contributed to its low sales. Only 45 were built, and, of those remaining, most are used by operators in the Middle East. However, some of the engineering work on the 747SP was reused with the development of the 747-300. In the 747SP, the upper deck begins over the section of fuselage that contains the wing box, not ahead of the wing box (as is the case with the 747-100 and 747-200). This same design was used in the 747-300 and newer 747-400, resulting in a stretched upper deck.

Design[edit]

Apart from having a significantly shorter fuselage and one fewer cabin door per side, the 747SP differs from other 747 variants in having simplified flaps and a taller vertical tail[5] to counteract the decrease in yaw moment-arm from the shortened fuselage. The 747SP uses single-piece flaps on the trailing edges, rather than the smaller triple-slotted flaps of standard 747s.

The SP could accommodate 230 passengers in a 3-class cabin or 331 (303 economy, 28 business) in a 2-class cabin, and a maximum of 400 passengers in one class.[citation needed]

Variants[edit]

The 747SP used as the NASA Stratospheric Observatory for Infrared Astronomy

From 2007 until 2022, a specially modified 747SP was used as the Stratospheric Observatory for Infrared Astronomy (SOFIA) astronomical observatory,[5] operated jointly by NASA and Germany's DLR. A former Pan Am and United Airlines aircraft acquired in 1997, its airframe was modified to carry a 2.5-meter-diameter reflecting telescope to high altitude, above 99.9% of the light-absorbing water vapor in the atmosphere. The telescope and its detectors covered a wide wavelength range from the near infrared to the sub-millimeter region; no window material is transparent over this whole range, so the observations were made through a 13 feet (4.0 m) square hole in the port upper quarter of the rear fuselage, aft of a new pressure bulkhead. A sliding door covered the aperture when the telescope was not in use.[11] Astronomers take data and control the instrument from within the normally pressurized cabin. Originally delivered to Pan Am and named "Clipper Lindbergh", the name was displayed in script on the port side of the aircraft.

In September 2022, SOFIA ceased operations after the conclusion of its final mission. The retirement was made both on the grounds of cost and suitability for the requirements of the decade to come.[12] The aircraft was later flown to the Pima Air & Space Museum in Tucson, Arizona, to be put on public display.[13]

Operators[edit]

Deliveries[edit]

Forty-five 747SP aircraft were built between 1974 and 1987.[14] The production line was ended in 1982 but reopened in 1987 to fulfill an order for the Abu Dhabi Amiri Flight.[15]

Type 1976 1977 1978 1979 1980 1981 1982 1983 1984 1985 1986 1987 1988 1989 Total
747-SP 14 4 2 5 9 6 4 1 45

Current operators[edit]

Pratt & Whitney engine testbed testing the PW1000G engine

As of September 2022, there were just three Boeing 747SPs still in active service, with 18 more stored and one preserved. The remaining 23 were either scrapped, otherwise destroyed, or abandoned.[14][verification needed]

In 2016, the last 747SP in commercial service was withdrawn from service after 40 years by Iran Air.[16][17] In 2020, the last aircraft in governmental use was stored by the Royal Flight of Oman,[18] and one of two aircraft remaining in VIP use by the Las Vegas Sands was written off by accidental damage sustained during Hurricane Laura.[19] The latter aircraft was scrapped soon afterwards.[20] The retirement of the SOFIA observatory left only three aircraft still in use as of September 2022, two of them for research purposes:

Former operators[edit]

This list also includes organizations that used the aircraft temporarily, besides main operators.

Records[edit]

There were three significant commercial around-the-world record-setting flights flown by 747SP: two operated by Pan Am and the other operated by United Airlines with the aircraft being "loaned" to Friendship Foundation, in order to raise money for the foundation. Those flights are:

Incidents and accidents[edit]

  • On February 19, 1985, China Airlines Flight 006, a 747SP-09 (aircraft registration N4522V) with 274 passengers and crew on a flight from Chiang Kai-shek Airport to Los Angeles suffered an inflight failure on engine number four. While the flight crew attempted to restore power the aircraft rolled to the right and started a steep descent from the cruising altitude of 41,000 feet, pulling 4.8 G and 5.1 G on two occasions. The captain managed to stabilize the aircraft at 9,500 feet and the aircraft diverted to San Francisco which was 550 km (297.0 nmi; 341.8 mi) away. Two passengers were injured and the aircraft suffered major structural damage.[56]
  • On October 5, 1998, a South African Airways Boeing 747SP-44 (ZS-SPF) operated by LAM Mozambique Airlines suffered an engine failure shortly after take-off from Maputo International Airport, Mozambique. The no. 3 engine suffered an uncontained failure – flying debris caused damage to the no. 4 engine and the wing. A fire broke out that couldn't be extinguished immediately, forcing an emergency landing. All 66 people on board survived. As a result, the aircraft was withdrawn from service and scrapped.[26]
  • On January 15, 2004, Iran Air Flight 800, a 747SP-86 (aircraft registration EP-IAC), faced hydraulic malfunction shortly after takeoff from Beijing Capital International Airport, the aircraft made an emergency landing, but the front landing gear collapsed. All people on board survived with no injuries.[57]
  • During the Yemeni Civil War, a 747SP owned by the President of Yemen, 7O-YMN, was struck by gunfire on March 19, 2015. Subsequent photographs show that the aircraft was then completely destroyed by fire afterward.
  • On August 27, 2020, a Las Vegas Sands Boeing 747SP-21 (VQ-BMS) was damaged beyond repair during Hurricane Laura[58] while undergoing maintenance. The right-hand wing fractured and the wing of another aircraft, believed to be BBJ N836BA, cut through the forward fuselage.

Aircraft on display[edit]

Specifications[edit]

747-100 top view, cross-section, front view, 747 side views: 747SP, -100, -400, -8I, and LCF

Note

  1. ^ JT9D, 233 passengers

See also[edit]

Related development

Aircraft of comparable role, configuration, and era

Related lists

References[edit]

  1. ^ "747 Model Summary". Boeing. Archived from the original on September 28, 2018. Retrieved December 29, 2010.
  2. ^ Norris, Guy; Wagner, Mark (1999). Modern Boeing Jetliners. Osceola, Wisconsin: Zenith Imprint. p. 20. ISBN 0-7603-0717-2.
  3. ^ Eden, Paul. (Ed). Civil Aircraft Today. 2008: Amber Books, pp. 92–3.
  4. ^ Jenkins, Dennis (2000). Boeing 747-100/200/300/SP (AirlinerTech Series, Vol. 6). North Branch, Minnesota: Specialty Press. p. 76. ISBN 1-58007-026-4.
  5. ^ a b c d e f g h i j k l m Eden 2008, pp. 96–7.
  6. ^ Pan Am orders baby jumbo Freight & Container Transportation October 1973 page 9
  7. ^ Pan Am's New Order Australian Transport November 1973 page 41
  8. ^ "The Boeing 747 Classics". Boeing Commercial Airplanes. Boeing. Retrieved January 23, 2009. Boeing also built the 747-100SP (special performance), which had a shortened fuselage and was designed to fly higher, faster and farther non-stop than any 747 model of its time.
  9. ^ Sutter, Joe (2006). 747: Creating the world's first jumbo jet and other adventures from a life in aviation. HarperCollins. p. 218. ISBN 0-06-088241-7.
  10. ^ a b Norris, Guy (1997). Boeing 747: Design and Development Since 1969. Motorbooks International. p. 74. ISBN 0-7603-0280-4.
  11. ^ "NAS's new airborne observatory". Sky and Telescope. 120 (4): 22–28. October 2010.
  12. ^ Klesman, Alison (September 29, 2022). "SOFIA flying observatory takes final flight". Astronomy.com. Retrieved September 30, 2022.
  13. ^ Waldek, Stefanie (December 13, 2022). "NASA's retired flying telescope heads to museum". Space.com. Retrieved December 15, 2022.
  14. ^ a b 747sp.com – Production List retrieved June 4, 2016
  15. ^ "The Story of the B747SP." 747sp.com. Retrieved: July 14, 2017.
  16. ^ Chini, Amin (June 21, 2016). "Iran Air Grounds Boeing 747SP, Suspends Kuala Lumpur Service (Jun 21, 2016)". AviationIran.com. Retrieved January 1, 2017.
  17. ^ "Production List – airframe 21093". 747SP.com. Retrieved January 1, 2017.
  18. ^ "21785 / 405 – Production List". Boeing 747SP Website. Retrieved April 30, 2022.
  19. ^ "Hurricane Laura destroys VQ-BMS". Boeing 747SP Website. August 27, 2020. Retrieved April 30, 2022.
  20. ^ "VQ-BMS Broken up". Boeing 747SP Website. June 22, 2021. Retrieved April 30, 2022.
  21. ^ MRJ Geared Turbofan Starts Flight Tests On 747SP Archived July 6, 2012, at the Wayback Machine Aviation Week & Space Technology
  22. ^ Donner, Ronald (May 10, 2012). "Pratt & Whitney's Flying Test Bed:The five engine 747". Retrieved October 20, 2020.
  23. ^ a b c d e f g h "Operators". Boeing 747SP Website. Archived from the original on April 13, 2013. Retrieved April 10, 2013.
  24. ^ Kinshasa Airways 747SP. Airliners.net (November 3, 2003).
  25. ^ Ben R. Guttery (1998). Encyclopedia of African Airlines. McFarland & Company. p. 125. ISBN 978-0-7864-0495-7.
  26. ^ a b "Boeing 747SP". Zap16.com. Retrieved December 30, 2010.
  27. ^ Air Namibia 747SP. Airliners.net.
  28. ^ Alliance 747SP. Airliners.net.
  29. ^ Avia 747SP. Airliners.net (January 3, 2006).
  30. ^ "Boeing 747SP Maluti ZS-SPC". SAA Museum. 2012. Retrieved January 4, 2012.
  31. ^ The Boeing 747SP of Trek Airways. Trekairways.co.za (September 4, 1993).
  32. ^ Argentinas 747SP. Airliners.net (January 5, 2012).
  33. ^ "Airfleets aviation – Airline Fleet, plane, airport : Boeing Airbus Embraer Atr Fokker Dash Beechcraft". airfleets.net.
  34. ^ "Vintage Airline Seat Map: American Airlines Boeing 747SP". Frequently Flying. February 11, 2011. Retrieved September 11, 2015.
  35. ^ "747SP". www.braniffinternational.org. Archived from the original on August 31, 2006.
  36. ^ Mercury Star News: Ballet's Head-turning Move, Fry's Owner Loans Decorated 747 For S.J. Dancers' Tour. Nl.newsbank.com (November 21, 2007).
  37. ^ Morgan, Tommy. "VQ-BMS Broken up". 747sp.com. 747sp. Retrieved February 8, 2024.
  38. ^ 1977/78: PanAm Routes. Airline Route (December 19, 2008).
  39. ^ 1992/93: UNITED International Network. Airline Route.
  40. ^ "United Airlines Fleet Details and History". www.planespotters.net. Retrieved November 13, 2021.
  41. ^ ch-aviation.com – Iran Air retires the B747SP from service November 26, 2014
  42. ^ Iraqi 747SP. Airliners.net (September 7, 2011).
  43. ^ Kazakhstan Airlines 747SP. Airliners.net (September 4, 1994).
  44. ^ "Qatar Airways Fleet Details and History". planespotters.net. Archived from the original on August 23, 2017. Retrieved September 12, 2017.
  45. ^ "N7477S (Ex VP-BAT) ferried to MZJ". October 29, 2019.
  46. ^ Mandarin Airlines will make maiden flight to Australia Archived June 1, 2012, at the Wayback Machine. None.
  47. ^ Saudi Arabian Airlines – History of the 80's. Saudiairlines.com.
  48. ^ Syrian Air 747s status at January 2012. Ch-aviation.ch.
  49. ^ Tajik Air 747SP. Airliners.net.
  50. ^ "Soldiers loyal to Yemen's former president storm Aden airport". The Guardian. Associated Press in Aden. March 19, 2015.
  51. ^ Tommy Mogren (April 6, 2015). "Yemenia 747SP damaged during attacks". B747SP Website.
  52. ^ Gulf News (July 17, 2015). "Aden may tilt scales in conflict" (PDF). Gulf News.
  53. ^ "21263 / 301 – Production List – Boeing 747SP Website". www.747sp.com.
  54. ^ "Red, White And Q Farewell For Qantas Aircraft". Qantas. March 4, 2002. Retrieved June 4, 2008.
  55. ^ "QFOM – Qantas 747 VH-EBQ". Qantas Founders Museum. Archived from the original on December 9, 2011. Retrieved January 4, 2012.
  56. ^ Aviation Safety Network report – 19 February 1985 accident. Aviation-safety.net.
  57. ^ Accident description for Boeing 747SP-86 EP-IAC at the Aviation Safety Network. Retrieved on 30 June 2023.
  58. ^ Accident description VQ-BMS. Aviation-safety.net
  59. ^ Fisher, Alise (December 8, 2022). "NASA's Retired SOFIA Aircraft Finds New Home at Arizona Museum". NASA. Retrieved December 12, 2022.
  60. ^ a b "747 Airplane Characteristics for Airport Planning" (PDF). Boeing Commercial Airplanes. May 2011.
  61. ^ a b "Type Certificate Data Sheet" (PDF). FAA. February 27, 2015. Archived from the original (PDF) on December 25, 2016. Retrieved July 1, 2015.
  62. ^ a b c "747-100/-200/-300/-SP" (PDF). Boeing. 2007.
  63. ^ "Boeing 747SP". Airliners.net.
  64. ^ a b c Gregory Maxwell (January 13, 2014). "The Life and Times of the Boeing 747SP".

Further reading[edit]

  • Davies, R.E.G. (2000). TWA : an airline and its aircraft. McLean, Virginia: Paladwr Press. ISBN 1-888962-16-X.
  • Baum, Brian (1997). Boeing 747SP. Miami, Florida: World Transport Press. ISBN 0-9626730-7-2.

External links[edit]

Media related to Boeing 747SP at Wikimedia Commons